02-14-2024, 09:21 PM
Thank you, Richard and Russ for the write up. You guys are the true example of “friends helping friends” It makes me proud to be a part of this group.
Pages: 1 2
02-14-2024, 09:21 PM
02-15-2024, 06:14 AM
Russ and Jack made some good points that got lost in my yarn spinning.
One, that HF compressor that was used to temporarily provide air to the potties was AMAZINGLY quiet. So quiet that one could buy the unit and remove the compressor from the skid and use it for a 120V compressor replacement. I don’t know about the longevity but it was very quiet and smooth.
Two, the reason this turned out to be such a tricky problem to diagnose and repair was that it was layered. There was one completely severed air line, and one partially severed air line. This was rare indeed, but with a severed air line you can’t build enough pressure to find the leaks.
Three, as Russ said, the use of listening devices was a huge aid to find some of the lesser leaks once we got the air lines repaired. Even those in the crowd with hearing deficits could hear the leaks with the devices.
Four, Jack brought his box of fittings, and I had mine. Having DOT fittings on site was crucial to the repair. Point being have a collection on board.
Five, although the coach was low mileage, stored indoors for years, and extremely clean. The previous owner(s) for whatever reason did not address air leaks. The air leaks left alone caused the pumps to run excessively filling the air system with water. Both pumps had to be replaced. The wet tank under the coach was newish, and the ping tank over the gen blower had a rust pinhole in addition to being FULL of water. The point is twofold, drain the air system regularly, and don’t ignore air leaks. For new owners, the cascade of costly damage that stems from unrepaired leaks may not be on their radar.
Yes the members of this group are special, any of you would have done the same if you were close by. I hope we always stay that way.
One, that HF compressor that was used to temporarily provide air to the potties was AMAZINGLY quiet. So quiet that one could buy the unit and remove the compressor from the skid and use it for a 120V compressor replacement. I don’t know about the longevity but it was very quiet and smooth.
Two, the reason this turned out to be such a tricky problem to diagnose and repair was that it was layered. There was one completely severed air line, and one partially severed air line. This was rare indeed, but with a severed air line you can’t build enough pressure to find the leaks.
Three, as Russ said, the use of listening devices was a huge aid to find some of the lesser leaks once we got the air lines repaired. Even those in the crowd with hearing deficits could hear the leaks with the devices.
Four, Jack brought his box of fittings, and I had mine. Having DOT fittings on site was crucial to the repair. Point being have a collection on board.
Five, although the coach was low mileage, stored indoors for years, and extremely clean. The previous owner(s) for whatever reason did not address air leaks. The air leaks left alone caused the pumps to run excessively filling the air system with water. Both pumps had to be replaced. The wet tank under the coach was newish, and the ping tank over the gen blower had a rust pinhole in addition to being FULL of water. The point is twofold, drain the air system regularly, and don’t ignore air leaks. For new owners, the cascade of costly damage that stems from unrepaired leaks may not be on their radar.
Yes the members of this group are special, any of you would have done the same if you were close by. I hope we always stay that way.
02-15-2024, 12:23 PM
Amazing work guys!!!
02-20-2024, 08:53 AM
Key broke off in door lock. Has anyone removed the door/panel to change the locks? I have a 2003 Newell 45
Pages: 1 2