You are not logged in or registered. Please login or register to use the full functionality of this board...


Fuel gauge kaput
#1

A few days ago we filled up with diesel and after a few miles I noticed the fuel gauge was reading 0.
I just pulled the vanity panel off the tank to access the sender and pulled the sender wire off and the gauge stayed on empty. Then I grounded the sender wire and the gauge went to full.
So what does this mean? bad sender unit or bad gauge?

Forest & Cindy Olivier
1987 log cabin
2011 Roadtrek C210P
PO 1999 Foretravel 36'
1998 Newell 45' #486 

1993 Newell 39' #337 
Reply
#2

bad sender

1993 Newell (316) 45' 8V92,towing an Imperial open trailer or RnR custom built enclosed trailer. FMCA#232958 '67 Airstream Overlander 27' '67GTO,'76TransAm,'52Chevy panel, 2000 Corvette "Lingenfelter"modified, '23 Grand Cherokee.
Reply
#3

Forest, if you have the polished stainless outer shell, I can give you some pointers on how to remove the sending unit without removing the tank. One mistake I made was not knowing that the new sending unit had a pin that has to be removed for it to work. Let's discuss tomorrow.

2001 Newell #579
tow a Honda Odyssey
fun car: 1935 Mercedes 500K replica
Reply
#4

Forest, if you ground your sender wire and the guage goes to full its your sender not the guage, by doing that you proved your guage is working

Love old schoolHeart
1976 Newell 8.3 cummins allison 6spd
1977 Newell 8.3 cummins allison 6spd
Reply
#5

Thanks, Newell is bringing a new sender to me.

Forest & Cindy Olivier
1987 log cabin
2011 Roadtrek C210P
PO 1999 Foretravel 36'
1998 Newell 45' #486 

1993 Newell 39' #337 
Reply
#6

Forest: did you check the ground wire at the sender. On the 93 coach the sender has two wires; one for the signal to the dash gauge and one that goes to ground on the chassis steel. It could be just the ground wire isn't passing current. Bypassing it temporarily to see if the gauge changes may save you the hassle of pulling the sender. I would also check the wiring between the sender and gauge by grounding the signal wire at the sender. All these tests will help verify whether it's the sender.

Jon Kabbe
1993 coach 337 with Civic towed
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)