Air Compressor Check Valve Problem - Printable Version

+- Newell Gurus (https://newellgurus.com)
+-- Forum: Technical Discussions (https://newellgurus.com/forumdisplay.php?fid=3)
+--- Forum: Suspension/Tires/Wheels (https://newellgurus.com/forumdisplay.php?fid=5)
+--- Thread: Air Compressor Check Valve Problem (/showthread.php?tid=5172)

---

Air Compressor Check Valve Problem - jpaulnorris - 09-20-2019

My compressor check valve is engaging after a short time (minute or less).  The coach is in the shop and our mechanic is troubleshooting but has not found the cause as of yet.  Are there any recurrent issues that would cause the compressor to kick off prematurely that you are aware of?

---

RE: Air Compressor Check Valve Problem - encantotom - 09-20-2019

if the compressor is just shutting off before reaching full pressure of your pressure switch, then i would first look at the well pump pressure switch that is right at the compressor. it is also possible the compressor itself is going out.

it is a simple system, a pressure switch that turns it on and off with a 20 psi delta and the compressor.

tom

---

RE: Air Compressor Check Valve Problem - folivier - 09-21-2019

On my 1993 and 1998 the pressure switch was in the right front compartment where the air blower for the generator is.  It could be in a couple places.

---

RE: Air Compressor Check Valve Problem - Richard - 09-21-2019

Ask the technician to dead head the compressor before the check valve. The assumption that the check valve is closing prematurely doesn’t sound right. First, the closure direction of the check valve is opposite the flow of the air, and second the normal check valve failure is that they fail to close.

Dead heading the compressor will isolate the problem to the compressor or the pressure switch. If the pressure switch is observed during a cycle, then it is easy to tell with the cover off, if the switch opens.

---

RE: Air Compressor Check Valve Problem - Latitude 28 - 09-21-2019

Out of curiosity, I have a Norgren regulator tee'd off at the pressure switch that is open to atmosphere.   What is the function of that regulator?

Thanks
Steve

---

RE: Air Compressor Check Valve Problem - rheavn - 09-21-2019

Steve,
The Norgren valve is a over pressure release.

---

RE: Air Compressor Check Valve Problem - Latitude 28 - 09-21-2019

That makes sense....so is it set to a release pressure just above the pressure switch cut out....am I thinking correctly on this?

---

RE: Air Compressor Check Valve Problem - Johnnyboy - 09-21-2019

Paul, 
Are you talking about your engine compressor or the 120v compressor?

---

RE: Air Compressor Check Valve Problem - Richard - 09-22-2019

Steve I think it is set much higher than that,, or else it would release when the engine compressor is running.

I found out the hard way that a Thomas compressor is capable of over 150 psi, enough to blow out an air bag. The HWH system has a signal to a second electrical box controlling the aux pump. That signal bypasses the pressure switches, hence the need for some sort of pressure protection.

---

RE: Air Compressor Check Valve Problem - rheavn - 09-22-2019

Steve,
My pressure release valve is set to release above 120 psi. If you search the Norgren valve part number you can review the specs of your valve.

---